An investigation on the adsorption of methylene blue from water by MnFe2O4-modified diatomite
Main Article Content
Abstract
The MnFe2O4/diatomite was obtained by wet chemical methods. The specific structure of the material has been determined by modern physicochemical methods. The results showed that the surface of diatomite was coated by the manganese/iron oxide nanoparticles. The prepared MnFe2O4/diatomite material is a good adsorbent for the removal methylene blue (MB) in water. The adsorption kinetics of MB on modulation materials are consistent with the pseudo-second-order kinetics model. The adsorption isotherms well followed the Langmuir isotherm model and maximal adsorption capacity of MB can read 151.52 mg/g at 323K. The adsorption behavior of MnFe2O4/modified is an endothermic and spontaneous process. The results show that MnFe2O4/diatomite is a promising adsorbent for the efficient removal of cationic dyes from wastewater.
Article Details
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.
Keywords
Adsorption, diatomite, dye, MnFe2O4/diatomite
References
Abdul Mubarak, N. S., Bahrudin, N., Jawad, A. H., Hameed, B., & Sabar, S. (2021). Microwave enhanced synthesis of sulfonated chitosan-montmorillonite for effective removal of methylene blue. Journal of Polymers and the Environment, 29(12), 4027-4039. DOI: 10.1007/s10924-021-02172-9.
Azha, S. F., Sellaoui, L., Engku Yunus, E. H., Yee, C. J., Bonilla-Petriciolet, A., Ben Lamine, A., & Ismail, S. (2019). Iron-modified composite adsorbent coating for azo dye removal and its regeneration by photo-Fenton process: Synthesis, characterization and adsorption mechanism interpretation. Chemical Engineering Journal, 361, 31-40. DOI: 10.1016/j.cej.2018.12.050.
Bayramoglu, G., Altintas, B., & Arica, M. Y. (2009). Adsorption kinetics and thermodynamic parameters of cationic dyes from aqueous solutions by using a new strong cation-exchange resin. Chemical Engineering Journal, 152(2-3), 339-346. DOI: 10.1016/j.cej.2009.04.051.
Belachew, N., & Bekele, G. (2020). Synergy of magnetite intercalated bentonite for enhanced adsorption of congo red dye. Silicon, 12(3), 603-612. DOI: 10.1007/s12633-019-00152-2.
Bui, V. T., Huynh, T. T. D., Tran, T. X. M., & Nguyen, M. T. (2021). An investigation on the adsorption of methyl orange from water by MnO2-modified diatomite. Vietnam Journal of Catalysis and Adsorption, 10(3), 16-25. DOI: 10.51316/jca.2021.023.
Chang, F., Qu, J., Liu, H., Liu, R., & Zhao, X. (2009). Fe–Mn binary oxide incorporated into diatomite as an adsorbent for arsenite removal: Preparation and evaluation. Journal of Colloid and Interface Science, 338(2), 353-358. DOI: 10.1016/j.jcis.2009.06.049.
Dai, D., Liang, H., He, D., Potgieter, H., & Li, M. (2021). Mn-doped Fe2O3/diatomite granular composite as an efficient Fenton catalyst for rapid degradation of an organic dye in solution. Journal of Sol-Gel Science and Technology, 97(2), 329-339. DOI: 10.1007/s10971-020-05452-3.
Dang, T.-D., Banerjee, A. N., Tran, Q.-T., & Roy, S. (2016). Fast degradation of dyes in water using manganese-oxide-coated diatomite for environmental remediation. Journal of Physics and Chemistry of Solids, 98, 50-58. DOI: 10.1016/j.jpcs.2016.06.006.
Elmoubarki, R., Mahjoubi, F., Tounsadi, H., Moustadraf, J., Abdennouri, M., Zouhri, A., El Albani, A., & Barka, N. (2015). Adsorption of textile dyes on raw and decanted Moroccan clays: kinetics, equilibrium and thermodynamics. Water resources and industry, 9, 16-29. DOI: 10.1016/j.wri.2014.11.001.
Ge, F., Ye, H., Li, M.-M., & Zhao, B.-X. (2012). Efficient removal of cationic dyes from aqueous solution by polymer-modified magnetic nanoparticles. Chemical Engineering Journal, 198, 11-17. DOI: 10.1016/j.cej.2012.05.074.
Gonawala, K. H., & Mehta, M. J. (2014). Removal of color from different dye wastewater by using ferric oxide as an adsorbent. International Journal of engineering Research and Applications, 4(5), 102-109.
Guibal, E., & Roussy, J. (2007). Coagulation and flocculation of dye-containing solutions using a biopolymer (Chitosan). Reactive and functional polymers, 67(1), 33-42. DOI: 10.1016/j.reactfunctpolym.2006.08.008.
He, Y., Jiang, D. B., Jiang, D. Y., Chen, J., & Zhang, Y. X. (2018). Evaluation of MnO2-templated iron oxide-coated diatomites for their catalytic performance in heterogeneous photo Fenton-like system. Journal of Hazardous Materials, 344, 230-240. DOI: 10.1016/j.jhazmat.2017.10.018.
Islam, M. A., Ali, I., Karim, S. M. A., Hossain Firoz, M. S., Chowdhury, A.-N., Morton, D. W., & Angove, M. J. (2019). Removal of dye from polluted water using novel nano manganese oxide-based materials. Journal of Water Process Engineering, 32, 100911. DOI: 10.1016/j.jwpe.2019.100911.
Kornaros, M., & Lyberatos, G. (2006). Biological treatment of wastewaters from a dye manufacturing company using a trickling filter. Journal of Hazardous Materials, 136(1), 95-102. DOI: 10.1016/j.jhazmat.2005.11.018.
Li, C., Zhong, H., Wang, S., Xue, J., & Zhang, Z. (2015). Removal of basic dye (methylene blue) from aqueous solution using zeolite synthesized from electrolytic manganese residue. Journal of Industrial and Engineering Chemistry, 23, 344-352. DOI: 10.1016/j.jiec.2014.08.038.
Liang, H., Zhou, S., Chen, Y., Zhou, F., & Yan, C. (2015). Diatomite coated with Fe2O3 as an efficient heterogeneous catalyst for degradation of organic pollutant. Journal of the Taiwan Institute of Chemical Engineers, 49, 105-112. DOI: 10.1016/j.jtice.2014.11.002.
Meshko, V., Markovska, L., Mincheva, M., & Rodrigues, A. (2001). Adsorption of basic dyes on granular acivated carbon and natural zeolite. Water research, 35(14), 3357-3366. DOI: 10.1016/S0043-1354(01)00056-2.
Pan, B., Qiu, H., Pan, B., Nie, G., Xiao, L., Lv, L., Zhang, W., Zhang, Q., & Zheng, S. (2010). Highly efficient removal of heavy metals by polymer-supported nanosized hydrated Fe (III) oxides: behavior and XPS study. Water Research, 44(3), 815-824. DOI: 10.1016/j.watres.2009.10.027.
Pang, J., Fu, F., Li, W., Zhu, L., & Tang, B. (2019). Fe-Mn binary oxide decorated diatomite for rapid decolorization of methylene blue with H2O2. Applied Surface Science, 478, 54-61. DOI: 10.1016/j.apsusc.2019.01.191.
Ramírez-Aparicio, J., Samaniego-Benítez, J. E., Murillo-Tovar, M. A., Benítez-Benítez, J. L., Muñoz-Sandoval, E., & García-Betancourt, M. L. (2021). Removal and surface photocatalytic degradation of methylene blue on carbon nanostructures. Diamond and Related Materials, 119, 108544. DOI: 10.1016/j.diamond.2021.108544.
Son, B. H. D. (2017). Phu Yen diatomite: modification and ít application to catalyst and adsorption. Hue University - College of Science, Vietnam.
Son, B. H. D., Mai, V. Q., Du, D. X., Phong, N. H., Cuong, N. D., & Khieu, D. Q. (2016). Catalytic wet peroxide oxidation of phenol solution over Fe–Mn binary oxides diatomite composite. Journal of Porous Materials, 24, 601-611. DOI: 10.1007/s10934-016-0296-7.
Sun, Z., Yao, G., Liu, M., & Zheng, S. (2017). In situ synthesis of magnetic MnFe2O4/diatomite nanocomposite adsorbent and its efficient removal of cationic dyes. Journal of the Taiwan Institute of Chemical Engineers, 71, 501-509. DOI: 10.1016/j.jtice.2016.12.013.
Supelano, G., Cuaspud, J. G., Moreno-Aldana, L. C., Ortiz, C., Trujillo, C., Palacio, C., Vargas, C. P., & Gómez, J. M. (2020). Synthesis of magnetic zeolites from recycled fly ash for adsorption of methylene blue. Fuel, 263, 116800. DOI: 10.1016/j.fuel.2019.116800.
Tseng, R.-L., & Tseng, S.-K. (2005). Pore structure and adsorption performance of the KOH-activated carbons prepared from corncob. Journal of Colloid and interface Science, 287(2), 428-437. DOI: 10.1016/j.jcis.2005.02.033.
Yu, T. T., Li, K. L., Guo, X. L., Li, F., Huang, J. M., & Zhang, Y. X. (2015). Facile decolorization of methylene blue by morphology-dependence δ-MnO2 nanosheets -modified diatomite. Journal of Physics and Chemistry of Solids, 87, 196-202. DOI: 10.1016/j.jpcs.2015.08.013.
Azha, S. F., Sellaoui, L., Engku Yunus, E. H., Yee, C. J., Bonilla-Petriciolet, A., Ben Lamine, A., & Ismail, S. (2019). Iron-modified composite adsorbent coating for azo dye removal and its regeneration by photo-Fenton process: Synthesis, characterization and adsorption mechanism interpretation. Chemical Engineering Journal, 361, 31-40. DOI: 10.1016/j.cej.2018.12.050.
Bayramoglu, G., Altintas, B., & Arica, M. Y. (2009). Adsorption kinetics and thermodynamic parameters of cationic dyes from aqueous solutions by using a new strong cation-exchange resin. Chemical Engineering Journal, 152(2-3), 339-346. DOI: 10.1016/j.cej.2009.04.051.
Belachew, N., & Bekele, G. (2020). Synergy of magnetite intercalated bentonite for enhanced adsorption of congo red dye. Silicon, 12(3), 603-612. DOI: 10.1007/s12633-019-00152-2.
Bui, V. T., Huynh, T. T. D., Tran, T. X. M., & Nguyen, M. T. (2021). An investigation on the adsorption of methyl orange from water by MnO2-modified diatomite. Vietnam Journal of Catalysis and Adsorption, 10(3), 16-25. DOI: 10.51316/jca.2021.023.
Chang, F., Qu, J., Liu, H., Liu, R., & Zhao, X. (2009). Fe–Mn binary oxide incorporated into diatomite as an adsorbent for arsenite removal: Preparation and evaluation. Journal of Colloid and Interface Science, 338(2), 353-358. DOI: 10.1016/j.jcis.2009.06.049.
Dai, D., Liang, H., He, D., Potgieter, H., & Li, M. (2021). Mn-doped Fe2O3/diatomite granular composite as an efficient Fenton catalyst for rapid degradation of an organic dye in solution. Journal of Sol-Gel Science and Technology, 97(2), 329-339. DOI: 10.1007/s10971-020-05452-3.
Dang, T.-D., Banerjee, A. N., Tran, Q.-T., & Roy, S. (2016). Fast degradation of dyes in water using manganese-oxide-coated diatomite for environmental remediation. Journal of Physics and Chemistry of Solids, 98, 50-58. DOI: 10.1016/j.jpcs.2016.06.006.
Elmoubarki, R., Mahjoubi, F., Tounsadi, H., Moustadraf, J., Abdennouri, M., Zouhri, A., El Albani, A., & Barka, N. (2015). Adsorption of textile dyes on raw and decanted Moroccan clays: kinetics, equilibrium and thermodynamics. Water resources and industry, 9, 16-29. DOI: 10.1016/j.wri.2014.11.001.
Ge, F., Ye, H., Li, M.-M., & Zhao, B.-X. (2012). Efficient removal of cationic dyes from aqueous solution by polymer-modified magnetic nanoparticles. Chemical Engineering Journal, 198, 11-17. DOI: 10.1016/j.cej.2012.05.074.
Gonawala, K. H., & Mehta, M. J. (2014). Removal of color from different dye wastewater by using ferric oxide as an adsorbent. International Journal of engineering Research and Applications, 4(5), 102-109.
Guibal, E., & Roussy, J. (2007). Coagulation and flocculation of dye-containing solutions using a biopolymer (Chitosan). Reactive and functional polymers, 67(1), 33-42. DOI: 10.1016/j.reactfunctpolym.2006.08.008.
He, Y., Jiang, D. B., Jiang, D. Y., Chen, J., & Zhang, Y. X. (2018). Evaluation of MnO2-templated iron oxide-coated diatomites for their catalytic performance in heterogeneous photo Fenton-like system. Journal of Hazardous Materials, 344, 230-240. DOI: 10.1016/j.jhazmat.2017.10.018.
Islam, M. A., Ali, I., Karim, S. M. A., Hossain Firoz, M. S., Chowdhury, A.-N., Morton, D. W., & Angove, M. J. (2019). Removal of dye from polluted water using novel nano manganese oxide-based materials. Journal of Water Process Engineering, 32, 100911. DOI: 10.1016/j.jwpe.2019.100911.
Kornaros, M., & Lyberatos, G. (2006). Biological treatment of wastewaters from a dye manufacturing company using a trickling filter. Journal of Hazardous Materials, 136(1), 95-102. DOI: 10.1016/j.jhazmat.2005.11.018.
Li, C., Zhong, H., Wang, S., Xue, J., & Zhang, Z. (2015). Removal of basic dye (methylene blue) from aqueous solution using zeolite synthesized from electrolytic manganese residue. Journal of Industrial and Engineering Chemistry, 23, 344-352. DOI: 10.1016/j.jiec.2014.08.038.
Liang, H., Zhou, S., Chen, Y., Zhou, F., & Yan, C. (2015). Diatomite coated with Fe2O3 as an efficient heterogeneous catalyst for degradation of organic pollutant. Journal of the Taiwan Institute of Chemical Engineers, 49, 105-112. DOI: 10.1016/j.jtice.2014.11.002.
Meshko, V., Markovska, L., Mincheva, M., & Rodrigues, A. (2001). Adsorption of basic dyes on granular acivated carbon and natural zeolite. Water research, 35(14), 3357-3366. DOI: 10.1016/S0043-1354(01)00056-2.
Pan, B., Qiu, H., Pan, B., Nie, G., Xiao, L., Lv, L., Zhang, W., Zhang, Q., & Zheng, S. (2010). Highly efficient removal of heavy metals by polymer-supported nanosized hydrated Fe (III) oxides: behavior and XPS study. Water Research, 44(3), 815-824. DOI: 10.1016/j.watres.2009.10.027.
Pang, J., Fu, F., Li, W., Zhu, L., & Tang, B. (2019). Fe-Mn binary oxide decorated diatomite for rapid decolorization of methylene blue with H2O2. Applied Surface Science, 478, 54-61. DOI: 10.1016/j.apsusc.2019.01.191.
Ramírez-Aparicio, J., Samaniego-Benítez, J. E., Murillo-Tovar, M. A., Benítez-Benítez, J. L., Muñoz-Sandoval, E., & García-Betancourt, M. L. (2021). Removal and surface photocatalytic degradation of methylene blue on carbon nanostructures. Diamond and Related Materials, 119, 108544. DOI: 10.1016/j.diamond.2021.108544.
Son, B. H. D. (2017). Phu Yen diatomite: modification and ít application to catalyst and adsorption. Hue University - College of Science, Vietnam.
Son, B. H. D., Mai, V. Q., Du, D. X., Phong, N. H., Cuong, N. D., & Khieu, D. Q. (2016). Catalytic wet peroxide oxidation of phenol solution over Fe–Mn binary oxides diatomite composite. Journal of Porous Materials, 24, 601-611. DOI: 10.1007/s10934-016-0296-7.
Sun, Z., Yao, G., Liu, M., & Zheng, S. (2017). In situ synthesis of magnetic MnFe2O4/diatomite nanocomposite adsorbent and its efficient removal of cationic dyes. Journal of the Taiwan Institute of Chemical Engineers, 71, 501-509. DOI: 10.1016/j.jtice.2016.12.013.
Supelano, G., Cuaspud, J. G., Moreno-Aldana, L. C., Ortiz, C., Trujillo, C., Palacio, C., Vargas, C. P., & Gómez, J. M. (2020). Synthesis of magnetic zeolites from recycled fly ash for adsorption of methylene blue. Fuel, 263, 116800. DOI: 10.1016/j.fuel.2019.116800.
Tseng, R.-L., & Tseng, S.-K. (2005). Pore structure and adsorption performance of the KOH-activated carbons prepared from corncob. Journal of Colloid and interface Science, 287(2), 428-437. DOI: 10.1016/j.jcis.2005.02.033.
Yu, T. T., Li, K. L., Guo, X. L., Li, F., Huang, J. M., & Zhang, Y. X. (2015). Facile decolorization of methylene blue by morphology-dependence δ-MnO2 nanosheets -modified diatomite. Journal of Physics and Chemistry of Solids, 87, 196-202. DOI: 10.1016/j.jpcs.2015.08.013.
Most read articles by the same author(s)
- Thi My Nhan Tran, Minh Thao Nguyen, Quoc Tri Tran, Van Tan Tran, A CASSCF/CASPT2 investigation on the electronic states of MnB20/−/+ clusters , Dong Thap University Journal of Science: No. 40 (2019): Part B - Natural Sciences
- Tan Tai Le, Thanh Luan Duong, Van Thang Bui, Studying synthesis and properties of inorganic–organic modified bentonite materials to treat blue methylene and phosphate in water , Dong Thap University Journal of Science: No. 31 (2018): Part B - Natural Sciences
- Van Tran Tran, Quoc Tri Tran, Minh Thao Nguyen, Trung Cang Phan, Van Tan Tran, Assignment of photoelectron spectrum of MnS− cluster by computational quantum chemistry , Dong Thap University Journal of Science: No. 21 (2016): Part B - Natural Sciences
- Thi Xuan Mai Tran, Viet Dung Tran, Van Thang Bui, An investigation on the adsorption of phenol red and Mn(II) by CTAB/Al-bentonite in water , Dong Thap University Journal of Science: Vol. 9 No. 3 (2020): Natural Sciences Issue (Vietnamese)
- Van Thang Bui, Thi Thuy Trang Nguyen, An investigation of Cu2+ adsorption by bentonite and acid-activated bentonite: Effects of clay amount, initial concentration and adsorption isotherm , Dong Thap University Journal of Science: No. 14 (2015): Part B - Natural Sciences
- Van Tran Tran, Quoc Tri Tran, Minh Thao Nguyen, Trung Cang Phan, Van Tan Tran, Investigation on the geometrical and electronic structures of MnS3−/0 clusters by computational chemistry and interpretation of the anion photoelectron spectrum , Dong Thap University Journal of Science: No. 23 (2016): Part B - Natural Sciences
- Van Thang Bui, Nghiên cứu điều chế và đặc trưng cấu trúc của vật liệu bentonit biến tính nhôm , Dong Thap University Journal of Science: No. 7 (2014): Part B - Natural Sciences
- Van Thang Bui, Thi Le Van Nguyen, The effects of cetyl trimethylammonium bromide concentration no organo-bentonite structure , Dong Thap University Journal of Science: No. 12 (2015): Part B - Natural Sciences